Dodge Cummins Diesel Forum banner
1 - 7 of 7 Posts

·
Registered
Joined
·
90 Posts
Discussion Starter · #1 ·
Have a couple 05 model 5.9 diesel powered dodges that I have been having all kinds of hell with in the past year or so.

First problems started on truck #1 a year or so ago. Had drive-ability problems which quickly turned into a slight knock and fuel in the crankcase..parked it, sent out injectors to get tested.. minus 30 bucks a piece to test them and 2 were bad. Checked compression and had a bum cylinder. Went ahead and bought two new injectors from Dodge and a used motor from a junk yard since I didn't have time to build this motor. Put new used motor in along with the set of 4 I had tested plus the two new ones. Good to go until this afternoon. Cruising along and it started blowing tons of oil out the breather pipe and lost oil pressure. PUlled injectors and will get tested monday.

Truck #2 about 6 months ago had oil dilluted with fuel dump out the breather going down the road like truck 1 today. Had 6 injectors tested, 1 was cracked and 2 were leaking down. Bought a entire new set of injectors from the dodge house. 2 months ago the exact same thing happened this time an injector took out a cylinder. Parked it, still parked and joined by truck #1

Whats the deal with 05's and these injectors???? Where can I buy a good set of injectors?????
 

·
Registered
Joined
·
90 Posts
Discussion Starter · #12 ·
I may not be very bright, but I just can't figure how bad fuel can make an injector body crack open. I don't know how bad the fuel is, I just fill up wherever there is a diesel pump I drive em in a big city and don't necessarily fill up at any one location
 
1 - 7 of 7 Posts
This is an older thread, you may not receive a response, and could be reviving an old thread. Please consider creating a new thread.
Top