Dodge Cummins Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 29 Results
  1. 89-93 Non-Powertrain
    To start I have searched to forums and tested a few things. Right now everything in the truck functions except starting with the key. The wiring is all from the 1985 D350 with a transplanted 89 Cummins. Ran awesome until I went to leave a car show turn the key everything turned on, turned to...
  2. 89-93 Powertrain
    I had my injectors tested last week and they were between 50-450 PSI below pop level, so I had them replaced with brand new Bosch (stock) injectors. I installed them and torqued them to 50lbs. None of them are leaking and I have fuel all the way up to the injectors, but I’m still not getting any...
  3. 89-93 Powertrain
    I spoke with a local diesel shop who suspect that my no-start issue is contributed to one or more failed injectors. They were backed up, so they gave me a cap that will screw onto each delivery valve on the VE Pump side and block off one injector at a time. The lines will be cracked on the...
  4. 3rd Gen. Powertrain
    Just as the title says I have a 2003 4x4 manual with 260,000 miles, when I turn the key one bump it does everything like it normally would, turn the key to start and nothing happens. The dash acts as if the starter was in fact turning. I checked the fuses and my starter Solenoid fuse was blown...
  5. 89-93 Non-Powertrain
    was parked (thankfully) & my fuse box fell down and i went to push it up & the truck shut off completely. wouldn’t start, crank or click. key turns fully, and dome lights, heater, door buzzer all work. battery & alternator are good. all fuses look good. if i connect the blue & red wire (back of...
  6. 3rd Gen. Powertrain
    2008 6.7 Cummins Hi, relatively new to the 6.7 and Chrysler. My serpentine belt blew off recently and broke the CPS. After replacing both I started it up and Noticed the water pump would also need replacing. After replacing the waterpump It started up again fine and I let it Idle up to...
  7. 98.5-02 Powertrain
    I have a 2001 Dodge Ram 2500 24V that stays inside a garage, Woke up last week warmed the truck up (4 degrees F), headed to get diesel (Guage was about a 1/4 full), then I stalled in the middle of the road about a mile down from my house. I grabbed about 5 gallons of Diesel in a can down the...
  8. 4th Gen Cab & Chassis
    I bought a 2011 Ram 3500 6.7l C&C Flood Damage truck as a project. When I first brought the truck home it was completely dead, no power to anything, I’ve replaced the TIPM, ECM, WIN Module, Starter, New Injectors and Crossover Tubes, New Turbo and Actuator, Camshaft Position sensor and adjusted...
  9. 3rd Gen. Powertrain
    Hello all I am currently having issue with my 07 ram 5.9 , no start/intermittent start. Batteries are fresh , starts with a shot of starting fluid, not good I know. Truck will start when I cap one injector , then when I put the fuel line back on, starts no issue, so there wasn’t much point to...
  10. 2019+ Non-Powertrain
    Help please my positive battery terminal rattled loose came off the truck died while driving I reconnected it and now the truck cranks but wont start it's bone stock I put brand new batteries in. When I turn the key to the on position the fuel pump does not appear to run I watched it with the...
  11. 2010-2012 Non-Powertrain
    Hi all, I’m turning to the knowledgeable people on the internet after my own troubleshooting is coming up short. A few weeks ago I had driven my truck on a 3 hour trip with no issues and no warning lights. The next morning I go to start the truck and my dash lights up with a service 4wd...
  12. 3rd Gen. Powertrain
    Hi everyone, hoping someone out here can help me with this project that I’ve been on for 5+ months. Bought a project 2003 ram 2500 5.9. Put a fresh crate engine into it with new turbo new injectors new cp3 pump, air dog, fuel lines, sensors, torque converter the list goes on. So short story when...
  13. 07.5 - 09 3rd Gen 6.7L Powertrain
    Howdy everyone. I’ve got a broken down 2007 Dodge 3500 with the 6.7 cummins outside of Yakima, WA. while on my way home to Texas. I was leaving the parking lot and it died quickly. I popped the hood and a ground strap from one of the battery terminals had come undone. I reattached it and...
  14. 2013-2018 Powertrain
    Alright, so ive read and researched this thing intensively for several days yet to find a solution. Back ground.. 2018 ram 3500 dually, 320k miles. Fully deleted at 200k with mild tune. Brought in the shop to pull head, throw in some new studs, all new gaskets, tap new exhaust manifold bolt...
  15. 94-98 Non-Powertrain
    Recently just got my motor reinstalled into the truck and have been fighting a fuel issue. The truck cranks but no sign of starting. The fuel shutoff comes up on start. I’ve opened the bleed bolt on top of the fuel filter as primed the lift pump numerous times and nothing comes out, every so...
  16. 98.5-02 Non-Powertrain
    Hello, I am new to the forum so please give me a little leeway here. Not sure if I’m in the right place, but here goes nothing. I have a 98 24v that runs great. After sitting all night it fires right up. But when I drive somewhere (and the truck gets warmed up) after I shut it off it will not...
  17. 2010-2012 Non-Powertrain
    So I recently changed the diesel filter on my 2010 6.7 ram and after changing the truck cranks but does not start. Does anyone have any ideas on what it could be... If so please let me know!
  18. 98.5-02 Powertrain
    Hey guys sorry to put up another one but couldn’t find exactly what I was looking for unfortunately and it’s been awhile since I’ve been in the 24v game. Ok so my buddies 01 started acting up on his drive to work the other day, spitting and sputtering then would clear up but did die at a light...
  19. 3rd Gen. Powertrain
    I have an 07 Cummins mega auto 4x4. Had a fire, been rebuilding, got new trans harness and firewall harness. I ended up splicing the block harness (couldn’t find one for 1.5 years) I cannot get it to start, first thing I’ve noticed is I can change gear at anytime with the key in, no brake...
  20. 98.5-02 Powertrain
    Hello, bought a used second gen. Sending u it and fuel tank straps were bad so I installed a sump and new fuel tank straps. Te lift pump in engine pay is a fass and it does work, blead fuel filter housing and injection pump and all fuel lines. Grid heater cycles just fine truck cranks and cranks...
1-20 of 29 Results
Top