Cummins Diesel Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 65 Results
  1. 2010-2012 Non-Powertrain
    2011 Dodge Cummins 3500, 6 speed manual, crew cab, long bed, 207,000 miles. My fuel light stays on all the time and fuel gauge shows empty. It use to be intermittent on when it would work, now it always shows empty. I replaced fuel sending unit in tank. I’ve also ran a gauge test and confirmed...
  2. 98.5-02 Powertrain
    I recently just bought a 2000 24 vlave with 227k miles. Was told when purchasing it that it had a fuel issue somwhere. I was able to test drive it before I handed any cash over. From first start up of the day it idles fine and has no issues just takes a while to get to temp but thats a diesel...
  3. 94-98 Performance Parts Discussion
    I went ahead and pulled the trigger on getting the Aggressor 60-64 but I'm not getting near the boost numbers and high EGTs. On the interstate running 5th gear ~ 2500 RPM maintaining 75 I'm producing maybe 2-3 lbs of boost and holding at 850 EGT. When I'm getting up to speed I can hit 15 lbs but...
  4. 98.5-02 Non-Powertrain
    Good morning to all who read. I got my truck running this morning and went to the gas station and then I noticed a big puddle of fuel under my truck, I popped the hood to see a decent sized leak coming from the top of the fuel filter housing. It is about -20F outside right now and I did not have...
  5. 2019+ General Discussion
    truck comes in crank no start, guy says he was messing with fuel filters and changed them, truck died on him while driving and it now cranks but will not start. Fuelrail pressure is commanding 4000psi but the truck is only seeing 2000psi while cranking. No codes are present, but he does have...
  6. 98.5-02 Powertrain
    So Its a 2000 2wd 2500 and I was cruising down the highway and my cylinder 1 injector line broke. I pulled off and got it towed home. Ordered a new line got it installed and then bled the system. This is not my first go round with bleeding the system even after changing a line. I can't get it...
  7. 03-07 Performance Parts Discussion
    Went to check after getting off the highway and having a weird idle and found some nice blow by, so now I get to rebuild the engine. Since I will be in there anyway I figured ill do some other work on the engine and just make a little more power. I was looking into doing a s366, dual cp3s (room...
  8. 98.5-02 Powertrain
    I am currently working on getting my dads 1998.5 dodge 3500 dually with the 6 speed manual transmission to run again. its the 2wd model. it has a fass lift pump in it as the only aftermarket modification. I just replaced the injectors with new oem ones and bled the fuel lines that run to the...
  9. 2013-2018 Non-Powertrain
    During the last couple of fuel filter changes, I've noticed I'm unable to drain the filter before removing it. I can attach a hose, but when I turn the knob to open things, little-to-nothing comes out. I could have sworn that when I first got the truck, I was able to drain it by attaching tubing...
  10. 89-93 Non-Powertrain
    Hey all, As I have been chasing my WIF light issue, I decided to drop the tank and take a look around. There was still a bunch of water in the bottom but it appears the water is getting in when it rains through a small hole in the top. It almost looks like it was meted but it’s not near...
  11. 03-07 Non-Powertrain
    Hello, I have searched the forums for similar issues but id like to throw my own post out and see what people have to say. The truck is an 03 24v, 245k miles. Like the title reads, the truck will sputter out and die at a half tank of fuel. Very hard to start back up and will drive for a few...
  12. 89-93 Non-Powertrain
    Hi all, Was replacing the fuel/water separator on a VE farm truck I picked up due to a WIF light. I also pumped about 15 gallons of old off road diesel out (almost all of it) and replaced with 5 gallons of fresh fuel. When I was priming the filter by cracking the bleeder it was bleeding dirty...
  13. 89-93 General Discussion
    Hey guys, new to the 12 valve world and I’m replacing the fuel water separator and cannot for the life of me figure out what the smaller o ring is for circled in the attached pic. Thanks! Silas
  14. 94-98 Non-Powertrain
    Today I was driving home from work and my truck died on me, all the sudden the accelerator stopped being responsive, then it shot to 3k rpm’s, then died. This happens every now and then and usually I pull over and let it idle and it’s fine but this time I get like a mile down the road and it...
  15. 89-93 Powertrain
    I could use some help figuring out why the fuel is at the injectors but won't start. I had the truck stall at idle several times over the last month but was able to crack the injector lines, re-prime and get it started. I assumed air was getting in so I started checking and or replacing every...
  16. 2013-2018 Powertrain
    Ive got a 2015 ram 2500 6.7 running a very mild del tune. I'm having issues with truck surging at idle when in gear. Fuel pressure is fluctuating up and down. Started a few days after changing filters. I've read on here that the FCA is known to cause issues when tuned so I replaced the FCA with...
  17. 07.5 - 09 6.7L Powertrain
    Hello, During idle, and idle only, my truck seems to fall in RPMs briefly then jump back up. It’s not a huge shift in RPMS but the best way I can describe it is it ‘breathes’. It slows quickly then jumps back up. Is this a fuel pressure issue, or what else could be causing this. I got the...
  18. 03-07 Powertrain
    hi there all I have a 2004, dodge ram, 3500 with 6 speed manual, 2 Wheel Dr. crew cab 5.9 Cummins. I recently pulled the engine out to overhaul it and all I did was disconnect all the connectors and wiring and pulled the engine out. I put the engine back together and put it in and I cannot get...
  19. 98.5-02 Performance Parts Discussion
    i have a 2000 dodge 2500 24 valve with a upgraded transmission and 4" exhaust a fass fuel lift pump and sump installed it has stock injectors. can i buy a tuner for 100hp on stock injectors ?
  20. 94-98 Powertrain
    Update we believe the problem to be a bad injection pump, fuel rack is sticking. (posting for a friend) No start, cranked, primed, bled, no start. The first thing he noticed is the p pump or ofv does not make a sound while priming?? You know that air hissing sound you get after pushing the...
1-20 of 65 Results
Top